Austro engine airworthiness directives
18 ADs in the reference matching Austro engine — from the Federal Register, checked every weekday. Applicability may depend on serial and effectivity: verify against the official AD before any maintenance action.
Reference last synced: 10/23/2026 04:00 UTC · 10,462 ADs indexed
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is superseding Airworthiness Directive (AD) 2023-20-03 for certain Austro Engine GmbH Model E4 and E4P engines. AD 2023-20-03 required repetitive engine oil analysis for aluminum content outside the acceptable limits and, if necessary, replacement of the pistons, piston rings, con-rods assembly, and crankcase or, as an alternative, replacement of the engine core. Since the FAA issued AD 2023-20-03, the manuf…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for certain Austro Engine GmbH (Austro) Model E4 and E4P engines. This AD was prompted by reports of engine failures and an investigation where cracks were discovered on the pistons. This AD requires repetitive borescope inspections (BSIs) for cracks on the pistons, and, if necessary, removal from service and replacement of the piston, and a fuel sample analysis…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for certain Austro Engine GmbH Model E4 and E4P engines. This AD was prompted by reports of engine failures and the determination that certain batches of cap screws, installed on the inner main bearing positions of the engine, were manufactured at the lower end of the material strength tolerance. This AD requires replacing certain cap screws with a part eligible…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for certain Austro Engine GmbH Model E4 and E4P engines. This AD is prompted by reports of piston failures and the determination that certain batches of pistons were manufactured with a dimensional deviation in the piston pin bore and piston diameter. This AD requires repetitive engine oil analysis for aluminum content outside the acceptable limits and, if neces…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is superseding Airworthiness Directive (AD) 2021-22-20 which applied to certain Austro Engine GmbH E4 and E4P model diesel piston engines. AD 2021-22-20 required, for engines with an affected cylinder head, inspection of the high pressure pump (HPP) driving gear and, depending on the results of the inspection, replacement of the HPP driving gear with a part eligible for installation. AD 2021-22-20 also requi…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is superseding Airworthiness Directive (AD) 2021-09-04 for all Austro Engine GmbH E4 and E4P model diesel piston engines. AD 2021-09-04 required replacing a certain oil pump as well as the oil filter and engine oil. This AD was prompted by reports of an oil pump blockage on E4 model diesel piston engines. This AD requires replacing a certain oil pump as well as the oil filter and engine oil. The FAA is issui…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for certain Austro Engine GmbH E4 and E4P model diesel piston engines. This AD was prompted by reports of failure of the high-pressure pump (HPP) driving gear and a subsequent determination that a batch of HPP driving gears may have been damaged during assembly. This AD requires, for engines with an affected cylinder head, inspection of the HPP driving gear and,…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for all Austro Engine GmbH E4 and E4P model diesel piston engines. This AD was prompted by a report of oil pressure loss on an E4 model diesel piston engine. This AD requires removing a certain oil pump from service and replacing it with a part eligible for installation. The FAA is issuing this AD to address the unsafe condition on these products.
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for all Austro Engine GmbH E4 and E4P model diesel piston engines. This AD was prompted by reports of an oil pump blockage on E4 model diesel piston engines. This AD requires replacing a certain oil pump as well as the oil filter and engine oil. The FAA is issuing this AD to address the unsafe condition on these products.
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is superseding Airworthiness Directive (AD) 2018-07-16 for all Austro Engine GmbH model E4 and E4P diesel piston engines. AD 2018-07-16 required initial and repetitive replacement of the waste gate controller and the control rod circlip. This AD retains the requirements of AD 2018-07-16 and requires engine modification by installing a waste gate control-rod fail-safe bridge and new spring- loaded circlip tha…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is superseding Airworthiness Directive (AD) 2018-18-02 for certain Austro Engine GmbH model E4 engines and all Austro Engine GmbH model E4P engines. AD 2018-18-02 required replacement of the timing chain and amending certain airplane flight manuals (AFMs) to limit the use of windmill restarts. This AD requires amendment of certain existing AFMs to limit the use of windmill restarts and removes the timing cha…
Airworthiness Directives; Austro Engine GmbH Engines
The FAA is adopting a new airworthiness directive (AD) for all Austro Engine GmbH model E4 and E4P diesel piston engines. This AD was prompted by reports of considerable wear of the timing chain and failure of fuel injectors on these engines. This AD requires replacement of the timing chain and fuel injectors on the affected Austro Engine GmbH model E4 and E4P diesel piston engines. The FAA is issuing this AD to add…
Airworthiness Directives; Austro Engine GmbH Engines
We are adopting a new airworthiness directive (AD) for certain Austro Engine GmbH model E4 engines and for all model E4P engines. This AD was prompted by reports of considerable wear on the timing chain on these engines. This AD requires replacement of the timing chain and amending certain airplane flight manuals to limit the use of windmill restarts. We are issuing this AD to address the unsafe condition on these p…
Airworthiness Directives; Austro Engine GmbH Engines
We are adopting a new airworthiness directive (AD) for all Austro Engine GmbH model E4 and E4P diesel piston engines. This AD requires replacement of the waste gate controller and the control rod circlip. This AD was prompted by reports of broken or disconnected turbocharger waste gate control rods on some engines. We are issuing this AD to address the unsafe condition on these products.
Airworthiness Directives; Austro Engine GmbH Engines
We are superseding airworthiness directive (AD) 2013-14-08 for all Austro Engine GmbH model E4 engines. AD 2013-14-08 required removing from service certain part number (P/N) waste gate controllers. This AD requires removing certain additional P/N waste gate controllers from service. This AD was prompted by several reports of power loss events due to fracture of the waste gate controller lever. We are issuing this A…
Airworthiness Directives; Austro Engine GmbH Engines
We are adopting a new airworthiness directive (AD) for all Austro Engine GmbH model E4 engines. This AD requires removing from service certain part number waste gate controllers. This AD was prompted by several reports of power loss events due to fracture of the waste gate controller lever. We are issuing this AD to prevent engine power loss or in-flight shutdown, which could result in loss of control and damage to…
Airworthiness Directives; Austro Engine GmbH Model E4 Diesel Piston Engines
We are superseding an existing airworthiness directive (AD) for the products listed above. That AD currently requires frequent inspections of the fuel pressure supply for excessive oscillations to determine if high-pressure (HP) fuel pumps have been exposed to damaging pressure oscillations. Pumps that have been exposed require replacement before further flight. This new AD requires the initial and repetitive inspec…
Airworthiness Directives; Austro Engine GmbH Model E4 Diesel Piston Engines
We are adopting a new airworthiness directive (AD) for the products listed above. This AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as: